Old-Motorcycle-Parts

Germany

                                 Dynamo Z  - Generator - Alternator 12V/130W                                   

                        The replacement for the original Bosch REA 60/6 alternator


 Installation options for the following motorcycles:


ZÜNDAPP

-K 800                                                                                                                                                                             1933 - 1938






We are pleased to present our new product.

The Dynamo Z, which is a replacement for the original Bosch REA60 / 6 alternators.

We dedicate this dynamo to the Zündapp K800.

This beautiful motorcycle will be moved for a long time on our streets.

Unfortunately, many old-timers have the big problem that the light machines are broken or have far too little

power.

So in the evening / night it was as if you drove in the candle light.

In response to this problem we have built the Dynamo Z in two versions - 12V / 130W with 10A continuous load

max. 15A and in 6V / 80W with 12A load max. 15A.

For the people who do not want to convert anything to your machines, we offer you the 6V version. For the People

who want to connect more modern 12V technology such as mobile phones or Navis or want to have more light we

recommend the 12V version.

Battery:

Our new Dynamo Z can be clamped on all types of batteries, but it can also be used without battery. 

 

E. Controller:

The old E. regulator in the motorcycles operates without transistors, which dissipate superfluous current to the

ground, which forced us to drive with switched on light.

Our new E. regulator works with polymer fuses that heat up in the event of a short circuit and block the current

flow.

The new Dynamos Z however only build as much power as you need at this moment with a small plus for the

battery.

It is possible to drive with 6W as well as with 65W, the regulator adjusts itself automatically.

So we can say that we have built an intelligent controller.

The new Dynamos Z do not overheat, are silent and maintenance-free.

Our dynamo is equipped with a special device which guarantees a 100% deactivation of the alternator when the

engine is switched off (ignition key out).

This allows us to ensure that our generator does not cause leakage currents.


Installation:

With the Dynamo Z in the 12V version the conversion of current collectors is unavoidable, as with all our Dynamos

in the 12V version.

Battery, bulb and ampere meter must be exchanged. The original 6V horn can remain, as long as it is not in

continuous operation. Short horns are no problem.

With Dynamo Z 6V nothing has to be changed.

This is connected exactly like the original alternator, except for a 15A fuse which must be installed before

Connection 51 + exactly as with the 12V version.

As far as these cooled again everything works again perfectly.  



Conclusion:

We can now proudly say that we have launched a product that will eliminate and eliminate all the electrical

Problems of  Zündapp K800.

We wish you all a good trip.

If you have further questions, please do not hesitate to contact us at: Old-Motorcycle-Parts-Germany.

 

Best regards

Old Motorcycle Parts

Germany



Ø Bulks:

• Lenght with shaft 8,46 inch

• Lenght without shaft 7,28 inch

• Width  3,54 inch

• Width of the rear cover: 3,62 inch

• Rear Cover Height: 2,16 inch

• Cone 6° Grad

•The bulks but areidentical as with orginal Bosch REA 60/6 alternator.


Ø Technical data:

• Voltage 12V

• 3 chamfering Generator

• Charging under load by 1000 RMP  6A = 78,0W - 13,5V

• Charging under load by 1400 RMP 6A = 86,4W - 14,4V

• Max load 15A

• Mass minus ( - )


Ø Technical requirements:

• Battery 12V ab 3,2Ah bis 14Ah

 • The battery is no matter how big it is, it goes without

• Ignition coil 12V


Ø Lighting bulbs for selection / example

• Headlight 12V - 40/45W or max 12V - 55/65W

• Parking light front minimum 12V/5W

• Low beam rear max.12V/5W

• Stop max.12V/10W

• Speedometer minimum. 12V/2W

• Fuse 15A  


►Electronic controller is included in delivery!


►On delivery include:

- Dynamo Z

- Elektronic controllers

- Warranty card

- Operating Instructions

- Packaging

---------------------------------------------------------------------------------------------------------------------------------------

Price:

Dynamo Z - 12V/150W

Part number: 00 7373 07Z 12 - Dynamo Z - 12V/150W - 550,00 €

---------------------------------------------------------------------------------------------------------------------------------------

Warranty:

2 years manufacturer warranty from date of purchase.

---------------------------------------------------------------------------------------------------------------------------------------

Operating Instructions for downloading.

Follow!